Product ID:ARDROX 9D6/D495A
MSDS Date:02/01/1990
FSC:6850
NIIN:00-145-0255
Kit Part:Y
MSDS Number: BJQMK

ARDROX INC

16961 KNOTT AVE
LA MIRADA, CA 90638-6015
US

Emergency Phone: 714-739-2821

Info Phone: 714-739-2821

Preparer: SHEREE L. KINZEL

Cage: 23373

BRENT AMERICA, INC.

LA MIRADA, CA 90638-6015 US

Telephone: 714-739-2821

Cage: 23373

METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)

CAS: 71-55-6

RTECS: KJ2975000

Fraction By Weight: <90%

OSHA PEL 350 PPM/450 STEL

ACGIH TLV: 350 PPM/450STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SEC-BUTYL ALCOHOL (SARA III)

CAS: 78-92-2

RTECS: EO1750000

Fraction By Weight: <5%

OSHA PEL 150 PPM

ACGIH TLV: 100 PPM; 9293

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES/SKIN:IRRITATION.
INHALATION:IRRITATION. INGESTION:INTENSE BURNING OF THE THROAT
FOLLOWED BY DROWSINESS, DULLNESS, NUMBNESS, CONVULSIONS AND DEATH
(SEVERE INGESTION). GENERAL:LOW LEVEL OF T OXICITY AND IRRITATION
CHRONIC:ASPIRATION CAN CAUSE CHEMICAL PNEUMONITIS, EDEMA,
HEMORRHAGE. CNS DEPRESSION.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES:PAINFUL BURNING AND STINGING, CONJUCTIVA
INFLAMMATION. SKIN:DEFATTING AND DRYING; IRRITATION.
BREATHED:IRRITATION, CNS DEPRESSION, HEADACHE, DIZZINESS, NAUSEA,
UNCONSCIOUSNESS. MAY BE FATAL IF OVEREXPOSURE ESPECIALLY IN
POORLY VENTILATED AREAS. OVEREXPOSURE CAN AFFECT THE
CNS,LIVER,KIDNEYS.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF SKIN AND
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE. CAN
CAUSE DERMATITIS.

First Aid:EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER. WASH SOILED
CLOTHING. INHALATION: REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH
RESUSCITAT ION IF NEEDED. KEEP VICTIM WARM AND GIVEOXYGEN IF
NEEDED. INGESTION: DO NOT INDUCE VOMITING. GIVE CONSCIOUS VICTIM
LOTS OF WATER. SEEK MEDICAL ATTENTION.

Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT. USE WATER SPRAY TO COOL NEARBY
CONTAINERS EXPOSED TO FIRE BUT CAN CAUSE FROTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS. DENSE SMOKE MAY BE
GENERATED IN A FIRE. ACIDIC GASES AND PHOSGENE MAY BE GEN.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT, ELIMINATE SOURCES
OF IGNITION, AND VENTILATE AREA AS REQUIRED. ABSORB SMALL SPILL
WITH INERT NON-COMBUSTIBLE INORGANIC MATERIAL. DIKE LARGE SPILLS
AND PREVENT RUNOFF TO SEWE R/WATERWAYS. PLACE WASTE IN DOT
APPROVEDCONTAINER
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM SOURCES OF IGNITION. KEEP CONTAINER CLOSED. PROTECT
FROM PHYSICAL DAMAGE. KEEP FROM FREEZING.
Other Precautions:DO NOT REUSE STORAGE CONTAINERS FOR ANYTHING ELSE.
KEEP CONTAINERS TIGHTLY CLOSED. KEEP FROM DIRECT SUNLIGHT AND AWAY
FROM WELDING, GRINDING AND DRILLING ACTIVITIES. GROUND ALL
EQUIPMENT. DON'T USE AR OUND FOOD, DRINK OR WHEN SMOKING.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR SELECTION. SCBA MAY BE NEEDED IN CONFINED AREAS.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS USUALLY ADEQUATE. SOME
USE MAY REQUIRE EXPLOSION-PROOF LOCAL VENTILATION.
Protective Gloves:CHEMICAL RESISTANT IMPERMEABLE GLOVES.
Eye Protection:NO CONTACTS SAFETY GLASSES / FACE SHIELD
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. INDUSTRIAL TYPE
WORK CLOTHING AND APRON AS REQUIRED TO AVOID PROLONGED OR REPEATED
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
KEY1:J7. THIS PRODUCT IS A KIT CONSISTING OF THREE PARTS.
CLEANER/REMOVER HAS PNI F, PENETRANT HAS PNI D AND DEVELOPER HAS
PNI E, SAME NSN. FORMULA CHANGED. FOR PREVIOUS FORMULATIONS, SEE
PNI A, B AND C, SAME NSN.

HCC:V2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:165F,74C
Vapor Pres:110
Vapor Density:4.5
Spec Gravity:1.3
Evaporation Rate & Reference:6.0 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE POWDER SUSPENDED IN COLORLESS LIQUID,
PLEASANT ETHER-LIKE ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ALKALIES, ALKALI METALS, ALUMINUM.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE AND
OTHER POSSIBLE OXIDES, ACIDIC GASES, PHOSGENE.

Waste Disposal Methods:WASTE MATERIAL WILL LIKELY BE A LAND-BANNED
HAZARDOUS WASTE. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. MANUFACTURER INDICATES USING
A SPECIALIST DISPOSAL COMP ANY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.